燃煤电厂大气污染物“近零排放”技术研究及工程应用

王树民; 宋 畅; 陈寅彪; 孙 平

燃煤电厂大气污染物“近零排放”技术研究及工程应用

1.
中国神华能源股份有限公司国华电力分公司, 北京 100025
2.
神华国华北京电力研究院有限公司, 北京 100025

基金项目: 国家高技术研究发展计划(863)项目(2013AA065404)

计量
- 文章访问数: 7722
- HTML全文浏览量: 31
- PDF下载量: 7986
- 被引次数: 0
出版历程
- 刊出日期: 2015-04-25

Technology Research and Engineering Applications of Near-Zero Air Pollutant Emission Coal-Fired Power Plants

1.
China Shenhua Energy Company Limited Guohua Power Branch, Beijing 100025, China
2.
Shenhua Guohua Beijing Electric Power Research Institute Co., Ltd., Beijing 100025, China

摘要

摘要:
在燃煤电厂实现大气污染物“近零排放”过程中,烟尘控制技术是关键,通过对除尘、脱硫、脱硝等先进环保技术的系统比较,提出了燃煤电厂大气污染物“近零排放”技术路线. 在地处长三角的国华舟山电厂4号机组采用高效低氮燃烧+SCR(选择性催化还原法)脱硝+旋转电极除尘+海水脱硫+湿式静电除尘的技术路线,ρ(烟尘)、ρ(SO₂)、ρ(NO_x)的实际排放值分别为2.46、2.76、19.80 mg/m³；在地处京津冀的国华三河电厂1号机组,采用高效低氮燃烧+SCR脱硝+低温省煤器+静电除尘(高效电源)+湿法脱硫+湿式静电除尘的技术路线,ρ(烟尘)、ρ(SO₂)、ρ(NO_x)的实际排放值分别为5、9、35 mg/m³. 实践表明,立足国情走煤炭清洁高效利用之路,燃煤电厂可以在低成本下实现大气污染物的“近零排放”. 通过对技术路线优化、低浓度污染物在线测量技术及“近零排放”中存在的一些问题进行分析和探讨,提出了燃煤电厂大气污染物控制技术的研究和发展方向. 估算结果表明,如果全国燃煤机组自2015年起采用“近零排放”技术,5 a内烟尘、SO₂、NO_x年均减排率分别可达19.0%、18.9%、18.5%.
- 燃煤发电 /
- 近零排放 /
- 技术路线 /
- 湿式静电除尘 /
- 在线测量
Abstract:
Abstract:Particulate matter control technology is extremely significant in the process of near-zero emission flue gas purification for coal-fired power plants. Advanced technologies for dust-removal, desulfurization and denitrification in power plants were comprehensively analyzed, and a near-zero air pollutant emission technology roadmap was proposed. The roadmap, including high efficiency and low NO_x burners, full load SCR, rotating electrode electrostatic precipitation, seawater desulphurization and west electrostatic precipitation, were developed and applied in the Shenhua Guohua Zhoushan Power Plant located in the Yangtze River Delta Region. The particulate matter, sulfur dioxide and nitrogen oxide emissions were reduced to less than 2.46,2.76 and 19.80 mg/m³ respectively from the newly built unit. Similarly, the Shenhua Guohua Sanhe Power Plant located in the Beijing-Tianjin-Hebei Region adopted the roadmap of high efficiency and low NO_x burners, full load SCR, low temperature economizer, dry electrostatic precipitation, wet FGD and west electrostatic precipitation. The particulate matter, sulfur dioxide and nitrogen oxide emissions were reduced to less than 5,9 and 35 mg/m³ respectively in the retrofit unit. Practice has proved that clean coal utilization is extremely effective based on China's national conditions. Clean and high-efficiency coal-fired power plants can achieve “near-zero emissions”of air pollutants with low cost. By analyzing the roadmap optimization, technologies for online measurement of low concentrations of contaminants and existing problems of “near zero emissions” , an R&D direction for coal-fired power plant air pollutant emission control technology was proposed. Supposing that near-zero emissions technology was applied in coal-fired power plants all over China in five years starting from 2015, the annual mean reduction rate of particulate matter, sulfur dioxide and nitrogen oxides would reach 19.0%, 18.9% and 18.5%, respectively.
- coal-fired power plants /
- near-zero emissions /
- technology roadmap /
- wet electrostatic precipitator /
- online measurement

HTML全文

参考文献(27)

[1]	姜雨泽,宋荣杰.火电厂除尘技术的发展动态研究.环境科学与技术,2008,1(8):59-64.JIANG Yuze,SONG Rongjie.Development of dedust technology for coal-fired power plants.Environmental Science & Technology (China),2008,1(8):59-64.
[2]	TOSHIAKI M,TADASHI O,MINUOM Y.Improvement of reliability for moving electrostatic type electrostatic precipitator//ICESP X-Australia.Queensland,Australia:ICESP,2006:1-10.
[3]	崔占忠,龙辉,龙正伟,等.低低温高效烟气处理技术特点及其在中国的应用前景.动力工程学报,2012,2(2):152-158.CUI Zhanzhong,LONG Hui,LONG Zhengwei,et al.Technical features of lower temperature high efficiency flue gas treatment system and its application prospects in China.Power Engineering,2012,2(2):152-158.
[4]	GRASS N,HARTMANN W,KLOCKNER M.Application of different types of high-voltage supplies on industrial electrostatic precipitators.IEEE Transactions on Industry Applications,2004,0(6):1513-1520.
[5]	徐巧生.旋转极板电除尘改造工程//燃煤电厂除尘新技术应用暨除尘器改造技术交流论文集.杭州:中国电力科技网,2014.
[6]	LIN Guanyu,TSAI Chuenjinn,CHEN Shengchieh,et al.An efficient single-stage wet electrostatic precipitator for fine and nanosized particle control.Aerosol Science and Technology,2010,4:38-45.
[7]	莫华,朱法华,王圣,等.湿式电除尘器在燃煤电厂的应用及其对PM_2.5的减排作用.中国电力,2013,6(11):62-65.MO Hua,ZHU Fahua,WANG Sheng,et al.Application of WESP in coal-fired power plants and its effect on emission reduction of PM_2.5.Electric Power,2013,6(11):62-65.
[8]	陈国榘.燃煤电厂烟尘治理技术改进//燃煤电厂除尘新技术应用暨除尘器改造技术交流论文集.杭州:中国电力科技网,2014.
[9]	王珲,宋蔷,姚强,等.电厂湿法脱硫系统对烟气中细颗粒物脱除作用的实验研究.中国电机工程学报,2008,8(5):1-7.WANG Hui,SONG Qiang,YAO Qiang,et al.Experimental study on removal effect of wet flue gas desulfurization system on fine particles from a coal-fired power plant.Proceeding in the CESS,2008,8(5):1-7.
[10]	蒯继玺.脱硫塔高效除雾技术的研究.保定:华北电力大学,2014.
[11]	张军,张涌新,郑成航,等.复合脱硫添加剂在湿法烟气脱硫系统中的工程应用.中国环境科学,2014,4(9):2186-2191.ZHANG Jun,ZHANG Yongxin,ZHENG Chenghang,et al.Application and experimental investigation of compound additive enhanced wet flue gas desulfurization process.China Environmental Science,2014,4(9):2186-2191.
[12]	王志轩,潘荔.我国火电厂烟气脱硫产业化发展建议.环境科学研究,2005,8(4):51-54.WANG Zhixuan,PAN Li.Suggestions for FGD industrialize of thermal power plants in China.Research of Environmental Sciences,2005,8(4):51-54.
[13]	FENSKE G D,WILLIAMS P J,PALMBERG C A.New life for a dual loop wet FGD system.Babcock & Wilcox Power Generation Group Technical Paper,2012:1-9.
[14]	史晓宏,毕春海.三河发电厂一期脱硫岛设计和运行的优化.神华科技,2010,8(4):63-65.SHI Xiaohong,BI Chunhai.The optimization of the design and circulate of FGD Ⅰ in sanhe power plant.Northwest Coal,2010,8(4):63-65.
[15]	SRIVASTAVA R K,JOZEWICZ W.Flue gas desulfurization:the state of the art.Air & Waste Management Association,2001,1(12):1676-1688.
[16]	KATSUO O,CHATURONG Y,KAZUO T,et al.Seawater flue gas desulfurization:its technical implications and performance results.Environmental Progress,2010,2(1):67-73.
[17]	朱环.基于能源消费的上海NO_x排放源与减排费用效果分析.环境科学研究,2012,5(8):947-952.ZHU Huan.NO_x emission calculation and cost-benefit analysis of emission reduction in Shanghai based on energy consumption.Research of Environmental Sciences,2012,5(8):947-952.
[18]	郭凤,余剑,牟洋,等.宽工作温度烟气脱硝催化剂制备及反应机理研究.燃料化学学报,2014,2(1):101-109.GUO Feng,YU Jian,MU Yang,et al.Preparation of catalyst with wide working-temperature and the reaction mechanism of flue gas denitration.Journal of Fuel Chemistry and Technology,2014,2(1):101-109.
[19]	云端,邓斯理,宋蔷,等.V₂O₅-WO₃/TiO₂系SCR催化剂的钾中毒及再生方法.环境科学研究,2009,2(6):730-735.YUN Duan,DENG Sili,SONG Qiang,et al.Potassium deactivation and regeneration method of V₂O₅-WO₃/TiO₂ SCR catalyst.Research of Environmental Sciences,2009,2(6):730-735.
[20]	孙巍,晏乃强,贾金平.载溴活性炭去除烟气中的单质汞.中国环境科学,2006,6(3):257-261.SUN Wei,YAN Naiqiang,JIA Jinping.Removal of elemental mercury in flue gas by brominated activated carbon.China Environmental Science,2006,6(3):257-261.
[21]	汤顺林,冯新斌,商立海,等.贵阳市小型燃煤锅炉烟气中汞的形态及释放.环境科学研究,2004,7(2):74-76.TANG Shunlin,FENG Xinbin,SHANG Lihai,et al.Mercury speciation and emissions in the flue gas of a small-scale coal-fired boiler in Guiyang.Research of Environmental Sciences,2004,7(2):74-76.
[22]	BOOL L E,HELBLEJ J.A laboratory study of the partitioning of trace elements during pulverized coal combustion.Energy Fuels,1995,9(5):880-887.
[23]	王起超,沈文国,麻壮伟.中国燃煤汞排放量估算.中国环境科学,1999,9(4):318-321.WANG Qichao,SHEN Wenguo,MA Zhuangwei.The estimation of mercury emission from coal combustion in China.China Environmental Science,1999,9(4):318-321.
[24]	陈义珍,柴发合,薛志钢,等.燃煤火电厂汞排放因子测试设计及案例分析.环境科学研究,2006,9(2):49-52.CHEN Yizhen,CHAI Fahe,XUE Zhigang,et al.Sudy on mercury emission factors for coal-fired power plants.Research of Environmental Sciences,2006,9(2):49-52.
[25]	支国瑞,薛志钢,李洋,等.基于国内实测燃煤电厂烟气汞排放估算的不确定度.环境科学研究,2013,6(8):814-821.ZHI Guorui,XUE Zhigang,LI Yang,et al.Uncertainty of flue gas mercury emissions from coal-fired power plants in China based on field measurements.Research of Environmental Sciences,2013,6(8):814-821.
[26]	史晓宏,温武斌,薛志刚,等.300 MW燃煤电厂溴化钙添加与FGD协同脱汞技术研究.动力工程学报,2014,4(6):482-486.SHI Xiaohong,WEN Wubin,XUE Zhigang,et al.Study on simultaneous desulfurization and demercurization with CaBr2 in a 300 MW coal-fired power plant,Journal of Chinese Society of Power Engineering,2014,4(6):482-486.
[27]	叶勇健,冯琰磊,邓文祥,等.浙江国华宁海电厂三期扩建工程可行性研究.上海:华东电力设计院,北京国华电力有限责任公司,国华电力研究院,2013.